audelo-News-Reasons for excessive heat generation of roller ti

all category

Company news

Information

Your exclusive Consultant:Mrs.Wang

Telephone:13605213465

Address:Jiangsu Province mine in Xuzhou City Road No. 21

web:en.audelo.com

company profile

your are here:Home >news> Reasons for excessive heat generation of roller ti

Reasons for excessive heat generation of roller ti

Improper maintenance of roller tires will cause heat if they are not noticed during use. What should I do in this situation?

1、 Make it a habit to check the tire pressure at any time. Air pressure is the key to prolong the tire life. If the tire pressure is often 20% higher than the normal pressure, the tire life will be reduced by 10%; If it is often lower than 30% of the normal pressure, the tire life will be reduced by 52%.

2、 The air pressure must be consistent. The tire pressure is the life of the tire. If the pressure is too low, the deformation of the carcass will increase, and the sidewall will be prone to cracks. At the same time, excessive heat generation will lead to rubber aging, cord layer fatigue, and cord breakage.

3、 The habit of removing foreign matters in tires regularly. When the vehicle is driving on the road, there are often some stones squeezed into the cracks of the tire pattern. If these small stones are not removed in time, they will puncture the tire over a long period of time, leading to air leakage or tire blowout.

4、 Driving habits meet scientific requirements. When driving on the road with large camber, it is necessary to drive in the middle as far as possible to avoid and reduce the deviation of the vehicle's center of gravity and reduce the uneven tire wear caused by the increase of tire load on one side.

5、 The front and rear wheels maintain accurate orientation. Front wheel alignment has a great influence on the service life of tires, especially the front wheel toe in and front wheel camber. Front wheel camber will mainly accelerate the wear of tire shoulder, namely eccentric wear; The toe in of the front wheel is mainly to accelerate the wear of the inner and outer sides of the tire.

To purchase roller tires, contact Manager Wang 13605213465

Same as above on WeChat

Email: 2630750628@qq.com

Disclaimer Part of the content comes from the network! This article is only for exchange and learning. The copyright belongs to the original author. Some pictures and content cannot be contacted with the original author in time when they are pushed. If the source label is wrong or your rights and interests are infringed, please inform us and we will delete them immediately